Magellan MSS Manual de instalación

1 MAGELLAN MSS - Mobile Satellite Internet System HARDWARE INSTALLATION MANUAL For Internal Use Only Updated January 2006

10to help determine if a disturbance exists .) STEP 5 – Use a measuring tape to center the plate on the roof. Step 6 – Mark the corners of the dish

11 STEP 9 – Drill all marked pilot holes. Make sure that you only drill down only for the distance of the length of the bolt to avoid hitting any

12 STEP 13 – Using the marking you made earlier, gently lower the mounting plate on top of the dicor & pre-drilled holes. STEP 14 – The dicor sh

13 TRICK - If you have a curved roof, such as a Airstream trailer… you may use rubber washers between the dish plate and the mounting plate so t

14 STEP 19 Use of a long, narrow drill bit is needed to drill the hole from inside of the vehicle. Before you start your pre-drill hole, make sure

15 RUNNING CABLES IMPORTANT NOTE FOR DIRECTV USERS – The MAGELLAN works with the Universal Bracket Kit for DirecTV which will work with most DirecTV

16 STEP 24 – Drop the cable from the MAGELLAN down the hole you’ve just drilled in the roof. STEP 24B – The cable wrap (shown here in white) is poro

17 STEP 27 – Once the clamps are in place, seal the entry hole with a liberal amount of DICOR. Make sure to squeeze DICOR BEWTWEEN THE CABLES. Ma

18INTERNAL WIRING Below is a schematic of a correctly connected MAGELLAN system. There are 5 cables that come down from the MAGELLAN that connect

19 The DW6000 Direcway Modems will supply the Internet connection to the Linksys Router. A standard Ethernet cable runs from the single Ethern

2 Table of Contents HARDWARE INSTALLATION INTRODUCTION... 3 PRE-INSTALLATION –

20 MAKING COAX CABLES STEP 1 – Cut the Coax cable to length. Make sure the cut is clean STEP 2 – Place the Coax Use the Coax Stripper Tool No

21 If you are having trouble making the perfect cut on your cables, the razor blades inside of the stripper are adjustable. Use the Allen Wrench (3

22 STEP 8 - Place the coax connector into the connector crimper. Make sure the crimper handles are opened…and then close the head handle. Grip the

23CONNECTING THE DISH POWER SUPPLY The MAGELLAN system is powered by a 15VDC power supply that is included with the system. Locate the power wire f

24TROUBLESHOOTING Ground Control Technical Support is available 24-7 at 805-542-0688 or by email at [email protected]

25MAGELLAN SPECIFICATIONS BANDWIDTH SERVICE (Via Direcway) Download Speed…………………….. Normally 400 to 1500 Kbps Upload Speed…….………………….. Normally 3

3HARDWARE INSTALLATION INTRODUCTION The installation of a MAGELLAN MSS (Mobile Satellite System) will normally take a full working day, and probably

4• Whether or not they want DirecTV* (which may affect which satellite Direcway Satellite they commission to…See *note) • The customer credit card

5interference from AC power lines, make sure that you DO NOT run the cables parallel with any AC power cable (that also be inside of the roof). IMPO

6TOOLS FOR AN INSTALLATION Below are the tools you will need to perform a mobile installation. Making sure you have the proper installation tools w

7 Scissors Flashlight Extension Cord Power Bar (for the extension cord) Rope – To help lift heavy things to roof Level Wire cutters Ethe

8 Dielectric Grease –Auto Parts stores carry this. Self-Tapping Sheet Metal Screws Assorted hardware Colored Electrical Tape – To help mark cabl

9DISH INSTALLATION The MAGELLAN comes shipped in one box (120 lbs) with these items: SHIPPED ITEMS • The MAGELLAN ships with this equipment: • The